Benefit

An anti-icing program implemented by the Idaho Transportation Department resulted in a 83 percent decline in winter crash frequency.


20 March 2001
Statewide,Idaho,United States


Summary Information

A 29-mile section of US Highway 12, from Arrow Bridge to the city of Orofino in northern Idaho, has always been a challenge for Idaho Transportation Department (ITD) winter maintenance personnel. The highway, which is located deep in a canyon, receives low to moderate amounts of snow and is prone to frost and black ice formation. The highway is particularly hazardous to motorists because slick pavement conditions can persist for long periods of time on sharp curves and in shaded areas. Extremely high quantities of abrasives applied to improve traction were only temporarily effective. In 1997, the ITD District 2 Maintenance Engineer decided to implement an anti-icing program to improve productivity and safety.

A chemical storage facility was installed in the maintenance yard to contain the anti-icing agent, liquid magnesium chloride. The storage facility included two 6,900-gallon tanks and an electric pump used for chemical circulation and truck loading. When inclement weather was forecast, a truck with a 1,500-gallon tank and a truck with a 1,000-gallon tank were used in concert with spray controls to pre-treat the highway with liquid magnesium chloride. Application rates varied from roughly 10 to 50 gallons per lane mile depending on the type of forecasted weather event. After initial application, maintenance crews regularly checked the status of four “indicator areas” along the highway. When frost on shoulder lanes began to migrate into travel lanes, the highway was retreated to ensure that the chemical concentration did not fall below effective levels.

A before/after study was conducted to determine winter maintenance trends over the period from Winter 1991/1992 to Winter 1999/2000. Yearly averages of labor hours, abrasive quantities, and accident frequency were calculated to compare the periods prior to and following inception of the anti-icing program in 1997. Comparison results are shown in the table below.

Comparison Table

Average Labor Hours
Average Abrasive Quantities
Average Number of Accidents
Before 1997
650
1475 m3
16.2
After 1997
248
247 m3
2.7
Amount Reduced
402
1228 m3
13.5
Percent Reduced
62%
83%
83%


The US 12 anti-icing program was a tremendous success. Depending upon precipitation amount, humidity and pavement temperature; a single application of liquid magnesium chloride was typically effective for three to four days. The program has reduced labor hours by 62 percent, abrasives usage by 83 percent, and winter accident frequency by 83 percent. The successes of District 2 and other ITD districts have fueled expansion of anti-icing programs throughout the state.

*

Benefit Comments

No comments posted to date

Comment on this Benefit

To comment on this summary, fill in the information below and click on submit. An asterisk (*) indicates a required field. Your name and email address, if provided, will not be posted, but are to contact you, if needed to clarify your comments.



Source

Anti-Icing Success Fuels Expansion of the Program in Idaho

Author: Breen, Bryon D.

Published By: Idaho Transportation Department (ITD), Snow and Ice Pooled Fund Cooperative Program

Source Date: 20 March 2001

URL: http://www.sicop.net/US-12%20Anti%20Icing%20Success.pdf

Rating

Average User Rating

0 ( ratings)

Rate this Benefit

(click stars to rate)


Goal Areas

Safety

Typical Deployment Locations

Rural Areas

Keywords

road weather vehicle tracking, winter maintenance vehicle

Benefit ID: 2001-00214